MKH-700容量法库仑法混合型卡尔费休水分仪
MKH-700容量法库仑法混合型卡尔费休水分仪
Hybrid Karl Fischer Moisture Titrator
混合型卡尔费休水分测定仪MKH-700是京都电子工业(KEM)新产品,也是世界上SC将容量滴定法和库仑电量法结合的卡尔费休水分测定仪。使用先进设计理念的”Hybrid混合滴定法”,可快速并精确测量样品中水分含量,另外无需使用标准物质即可执行滴定度自动校正。
容量法或库仑法卡尔费休水分仪进行测量时必须控制样品量。混合型水分测定法(Hybrid Method)依据测量池中水分含量,自动执行容量滴定法和库仑电量法的并行运作,具有高速、高精度的测量结果。
电解标定测量系统。只需通过一个按键,自动进行容量法卡尔费休试剂滴定度的测试,没有人为误差且不需要使用纯水或标准物质执行滴定度校准。
MKH-700容量法库仑法混合型卡尔费休水分仪 主要特点:
1. 混合滴定法: 即使样品中水分含量过高,也可进行快速和高精度测试。
2. 电解标定测量系统: 自动执行滴定度校正,没有人为误差,精确度高。
3. 一体型测量池: 容量法库仑法共用滴定杯,确保密封性和提高便利性。
4. 发生电极可更换式隔膜: 可以拆卸发生电极的隔膜,便于清洁和保养。
5. 三种测量模式: 容量法或库仑法或混合法均可在同一个测量池中进行。
6. 标配USB接口: 可使用U盘储存测量方法和测试结果作为电子记录。
MKH-700容量法库仑法混合型卡尔费休水分仪 技术参数:
库仑分析法(Coulometric Method)
测量范围: 10μg~300mg H2O。
精确度: 测量1mg标准水样,相对标准偏差小于0.3%,分辨率: 0.1μg。
容量分析法(Volumetric Method)
测量范围: 100μg~500mgH2O (依据KF试药滴定度)。
滴定管: 容量: 10mL,重复性: ±0.005mL。
混合分析法(Hybrid Method)
测量范围: 10μg~500mg H2O。
精确度: 测量10mg标准水样,相对标准偏差小于0.3%,分辨率: 0.1μg。
电解标定测定法(Electrolysis)
测量范围: 容量法卡尔费休试剂滴定度1~5mg/mL。
精确度: 相对标准偏差小于1%。
界面: RS-232C,SS-BUS,LAN。
电源: AC100~240V, 50/60HZ, 80W。
尺寸: 141(W)x296(D)x383(H)mm。
重量: 约4.5kg。
Application 适用标准
Standards
Number
DetailsASTM
D1533
Standard Test Method for Water in Insulating Liquids by Coulometric Karl Fischer Titration
绝缘液体中水的试验方法(卡尔费休反应法)
D1744
Standard Test Method for Determination of Water in Liquid Petroleum Products by Karl Fischer Reagent
用卡尔费休试剂测定液化石油产品中水的试验方法
D4928
Standard Test Method for Water In Crude Oils by Coulometric Karl Fischer Titration
库仑电量卡尔费休法测定原油含水量的方法
D6304
Standard Test Method for Determination of Water in Petroleum Products, Lubricating Oils, and Additives by Coulometric Karl Fischer Titration
利用库仑电量卡尔费休滴定法测定石油产品、润滑油、添加剂中水含量的试验方法E203
Test Method for Water Using Volumetric Karl Fischer Titration
卡尔费休容积滴定测量水的标准试验方法ISO
760
Determination of water – Karl Fischer method (General method)水的测定卡尔费休法(通用方法)Specification 全能通用型电量法+容量法卡尔费休水分仪
Specification
全能通用型电量法+容量法卡尔费休水分仪
Contents
说明Type
仪器类型
Hybrid Karl Fischer Moisture Titrator
卡尔费休“电量法”滴定Model
仪器型号
MKH-700
Measuring method
测量模式1
Karl Fischer Coulometric titration
卡尔费休“电量法”滴定Measuring range
测量范围
Water content
水分量
10μg - 300mg H2OPrecision
精度
RSD(重复性)
相对标准偏差
less than 0.3% (n=10)
(10次)测量1mg H2O标准甲醇水时,相对标准偏差在0.3%以下Display resolution
显示精度
0.1μgControl method
控制方式
Constant current pulse time control
恒电流脉冲时间控制Endpoint detection
终点检测
Alternate current polarization method with a twin Platinum electrode
双铂金电极的交流极化法EP sense method
终点判定
Selective drift stability or Limit measurement time
可选择按漂移值稳定度判定终点,或以测量限制时间结束来判定终点Titration form
滴定模式
Normal titration/Back titration
正滴定/反滴定,逆滴定Titration cell
滴定池类型
Two component cell
有隔膜双液电解池Required reagent
试剂要求
Anolyte(阳极液)
100mLCatholyte(阴极液)
5mL
Measuring method
测量模式2
Karl Fischer Volumetric titration
卡尔费休“容量法”滴定Measuring range
测量范围
Water content
水分量
100μg - 500mg H2O
(depends on KF reagent factor取决于KF试剂的滴定度)Concentration
水分浓度
1ppm - H2OBurette precision
滴定管
Volume
滴定管容量
10mLResolution
精度
1/20,000(二万分之一)Discharge precision
滴定精度
±0.015mLRepeatability
重复性
±0.005mLEndpoint detection
终点检测
By polarized potential level detected with a twin Platinum electrode
双铂金检测电极,检测液阻抗补偿极化电位EP sense method
终点判定方法
Detection of potential level maintained during End preset time. End time range : 1 - 99s.
可选择按恒电位稳定来判定终点,或以测量限制时间(1 - 99秒)结束来判定终点
Titration form
滴定模式
Normal titration/Back titration
Add the optional additional burette unit.
正滴定/反滴定,逆滴定(逆滴定需要增加一个滴定单元)
Required solvent
试剂要求
50 - 150mL
Measuring method
测量模式3
Karl Fischer Coulometric titration
Karl Fischer Volumetric titration
电量法+容量法组合(Hybrid 模式)
Measuring range
测量范围
Water content
水分量
10μg - 500mg H2OPrecision
精度
RSD(重复性)
相对标准偏差
less than 0.3% (n=10)
(Karl Fischer reagent factor 3mg/mL)
(10次)测量1mg H2O标准甲醇水时,相对标准偏差在0.3%以下,(卡尔费休试剂的滴定度为3mg/mL)
Display resolution
显示精度
0.1μgControl method
控制方式
Automatic continuous titration 自动连续滴定
Constant current pulse time control 恒电流脉冲时间控制
Endpoint detection
终点检测
Alternate current polarization method with a twin Platinum electrode
双铂金电极的交流极化法EP sense method
终点判定方法
Selective drift stability or Limit measurement time
可选择按漂移值稳定度判定终点,或以测量限制时间结束来判定终点Titration form
滴定模式
Normal titration 正滴定Required reagent
试剂要求
Anolyte(阳极液)
100mLCatholyte(阴极液)
5mL
Measuring method
测量模式4
Factor measurement of reagent by electrolysis
全自动校正,以电解法测定卡尔费休试剂因数/滴定度Measuring range
测量范围
KF reagent
卡尔费休试剂
Reagent factor from 1 to 5
(With the provisions of dose volume)
卡尔费休试剂滴定度为1-5 ,按剂量体积的规定
Precision
RSD(重复性)
相对标准偏差
less than 1.0% (n=3)
(Dose volume 0.5mL, Reagent factor 3mg/mL)
(3次)相对标准偏差在1.0%以下,(卡尔费休试剂为0.5mL,滴定度为3mg/mL)
Control method
控制方式
Constant potential control
恒电位控制Endpoint detection
终点检测
Alternate current polarization method with a twin Platinum electrode
双铂金检测电极,检测液阻抗补偿极化电位EP sense method
终点判定方法
Drift stability
漂移值稳定Required reagent试剂要求
Anolyte(阳极液)
100mLCatholyte(阴极液)
5mLNumber of methods
预置存实验方法
Coulometric/ Volumetric
Hybrid
Up to 50
电量法/容量法 包括Hybrid 模式 Up to 50 (50组)Factor measurement
因数测量
1Data storage
数据记录
On-board memory
仪器主机
300 dataExternal memory
扩展存储
Memory card (Compact Flash), USB flash
CF记录卡 ,USB储存设备GLP conformance GLP 认证
Yes 仪器符合GLP 认证External I/O
(Measuring unit)
测量单元外部接口
RS-232C
1ch (for Multiple sample changer/ Evaporator)
连接多样品转换器或者水分蒸发器SS-BUS
1ch (for APB) 连接 APB 滴定单元K-NET
1ch (for Main control unit) 连接控制单元External I/O
(Main control unit)
控制单元外部接口
COM1/COM2
2ch (for dot matrix printer, electronic balance, PC)
2个,可连接针式打印机,电子天平,PCCF card
1ch (Compact Flash) CF 卡插槽USB
1ch (USB flash) USB储存设备K-NET
2ch (Measuring unit) 可同时连接2组测量单元Main control unit
触控屏
8-inch LCD (163.2 x 122.4mm)
8英寸彩色液晶显示触控屏256 colors 800 x 600 dots
256色 ,分辩率 800 X 600Language
语言支持
English / Japanese 英语 /日本语Ambient conditions环境要求
Temperature
温度
5 - 35°CHumidity
湿度
85%RH or below (no condensation)
环境湿度 < 85% (无结露)Power supply
电源要求
Measuring unit
测量单元
DC24V (Main unit)
AC100-240V ±10% 50-60Hz 2A (Comes with AC Adapter)
自带电源变压器
Main control unit
控制单元
DC12V 3A (Main unit)
AC100-240V ±10% 50-60Hz (Comes with AC Adapter)
自带电源变压器
Power consumption
功率Measuring unit
Stirrer
测量单元+磁力搅拌器
Approx. 80WMain control unit
控制单元
Approx. 20WDimensions
体积
Measuring unit
测量单元
141 (W) x 296 (D) x 383 (H) mm (not incl. tubing 不包括连接线 )Main control unit
控制单元
230 (W) x 285 (D) x 255 (H) mmStirrer/Cell
磁力搅拌器/滴定池
110 (W) x 230 (D) x 350 (H) mmdispenser
分配器
240 (W) x 170 (D) x 110 (H) mm (not incl. tubing不包括连接线 )Weight
Measuring unit
测量单元
Approx. 4.5kgMain control unit
控制单元
Approx. 2.0kgStirrer/Cell
磁力搅拌器/滴定池
Approx. 1.4kgdispenser
分配器
Approx. 0.6kgCE marking
CE 标志
Conforming to EN61326, EN61010-1, RoHS compliant
符合en61326,en61010-1,符合RoHS 0 1 2 3 4 5 6 6 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 3 5 6 7 8 9 0 1 0 9 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5